Hatco Glo-Ray GRSS-2418 Manual de Usario

Hatco plato calentador Glo-Ray GRSS-2418

Lee a continuación 📖 el manual en español para Hatco Glo-Ray GRSS-2418 (36 páginas) en la categoría plato calentador. Esta guía fue útil para 10 personas y fue valorada con 4.5 estrellas en promedio por 2 usuarios

Descargar PDF

Página 1/36

GLO-RAY®

Heated Stone Shelves

Plaques chauffantes en pierre

GRSS, GRSSB, GRSSR Series/Série

Installation and Operating Manual

Manuel d'installation et d'utilisation

I&W #07.05.166.00

(see page 2)

S'inscrire en ligne!

(voir page 19)

www.hatcocorp.com

Do not operate this equipment unless you

have read and understood the contents of

this manual! Failure to follow the

instructions contained in this manual may

result in serious injury or death. This

manual contains important safety

information concerning the maintenance,

use, and operation of this product. If

you’re unable to understand the contents

of this manual, please bring it to the

attention of your supervisor. Keep this

manual in a safe location for future

reference.

English = p 2

No opere este equipo al menos que haya

leído y comprendido el contenido de este

manual! Cualquier falla en el seguimiento

de las instrucciones contenidas en este

manual puede resultar en un serio lesión

o muerte. Este manual contiene

importante información sobre seguridad

concerniente al mantenimiento, uso y

operación de este producto. Si usted no

puede entender el contenido de este

manual por favor pregunte a su

supervisor. Almacenar este manual en

una localización segura para la referencia

futura.

Ne pas utiliser cet équipement sans avoir

lu et compris le contenu de ce manuel !

Le non-respect des instructions

contenues dans ce manuel peut entraîner

de graves blessures ou la mort. Ce

manuel contient des informations

importantes concernant l'entretien,

l'utilisation et le fonctionnement de ce

produit. Si vous ne comprenez pas le

contenu de ce manuel, veuillez le signaler

à votre supérieur. Conservez ce manuel

dans un endroit sûr pour pouvoir vous y

référer plus tard.

Français = p 19

WARNING

ADVERTENCIA

AVERTISSEMENT

2Form No. GRSSM-0213

CONTENTS

English

INTRODUCTION

The Hatco Glo-Ray®Heated Stone Shelf is designed to keep

prepared foods hot while blending into your décor. Heated

Stone Shelves will keep all foods at optimum serving

temperatures without affecting quality. These warmers have a

thermostatically-controlled heated base to extend the holding

times of most foods.

Glo-Ray Heated Stone Shelves are a product of extensive

research and field testing. The materials used were selected

for maximum durability, attractive appearance, and optimum

performance. Every unit is inspected and tested thoroughly prior

to shipment.

This manual provides the installation, safety, and operating

instructions for the Glo-Ray Heated Stone Shelf. Hatco

recommends all installation, operating, and safety instructions

appearing in this manual be read prior to installation or

operation of the Glo-Ray Heated Stone Shelf.

Safety information that appears in this manual is identified by

the following signal word panels:

WARNING indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

CAUTION indicates a hazardous situation which, if not

avoided, could result in minor or moderate injury.

NOTICE is used to address practices not related to

personal injury.

NOTICE

CAUTION

WARNING

Important Owner Information ..............................................2

Introduction...........................................................................2

Important Safety Information...............................................3

Model Descriptions...............................................................4

All Models...........................................................................4

GRSS Models.....................................................................4

GRSSR Models ..................................................................4

GRSSB Models ..................................................................4

Model Designation................................................................4

Specifications........................................................................5

Plug Configurations ............................................................5

Electrical Rating Charts......................................................5

Dimensions.........................................................................7

Installation .............................................................................9

GRSS and GRSSR Models................................................9

GRSSB Models ..................................................................9

Operation .............................................................................11

General .............................................................................11

Maintenance ........................................................................12

General.............................................................................12

Cleaning ...........................................................................12

Cleaning the Stone Surface .............................................12

Troubleshooting Guide ......................................................13

Options and Accessories...................................................14

Limited Warranty.................................................................18

Authorized Parts Distributors............................Back Cover

IMPORTANT OWNER INFORMATION

Record the model number, serial number, voltage, and

purchase date of the unit in the spaces below (specification

label on bottom of GRSS model, bottom of control box on

GRSSB and GRSSR models). Please have this information

available when calling Hatco for service assistance.

Model No. ________________________________________

Serial No. ________________________________________

Voltage __________________________________________

Date of Purchase __________________________________

Completing online warranty registration will prevent delay in

obtaining warranty coverage. Access the Hatco website at

www.hatcocorp.com, select the Parts & Service pull-down

menu, and click on “Warranty Registration”.

Business 8:00 AM PMto 5:00

Hours: Central Standard Time (C.S.T.)

(Summer Hours: June to September –

8:00 AM PMto 5:00 C.S.T.

Monday through Thursday

8:00 AM PMto 2:30 C.S.T. Friday)

Telephone: (800) 558-0607; (414) 671-6350

E-mail: partsandservice@hatcocorp.com

Fax: (800) 690-2966 (Parts and Service)

(414) 671-3976 (International)

Additional information can be found by visiting our web site at

www.hatcocorp.com.

24 Hour 7 Day Parts and Service

Assistance available in the United States

and Canada by calling 800-558-0607.

Form No. GRSSM-0213 3

IMPORTANT SAFETY INFORMATION

English

ELECTRIC SHOCK HAZARD:

• Plug unit into a properly grounded electrical receptacle

of the correct voltage, size, and plug configuration. If

plug and receptacle do not match, contact a qualified

electrician to determine and install the proper voltage

and size electrical receptacle.

• Remote mounted control enclosure must be mounted

on a vertical wall and installed in vertical position.

Mounting control enclosure in horizontal position may

result in collection of liquids and lead to an electric

shock.

• Turn OFF power switch, unplug power cord, and allow

unit to cool before performing any cleaning,

adjustments, or maintenance.

• DO NOT submerge or saturate with water. Unit is not

waterproof. Do not operate if unit has been submerged

or saturated with water.

• Unit is not weatherproof. Locate unit indoors where

ambient air temperature is a minimum of 70°F (21°C).

• This unit is not “jet-proof” construction. Do not use jet-

clean spray to clean this unit.

• Do not steam clean or use excessive water on unit.

• Do not pull unit by power cord.

• Discontinue use if power cord is frayed or worn.

• Do not attempt to repair or replace a damaged power

cord. The cord must be replaced by Hatco, an

Authorized Hatco Service Agent, or a person with

similar qualifications.

• This unit must be serviced by qualified personnel only.

Service by unqualified personnel may lead to electric

shock or burn.

• Use only Genuine Hatco Replacement Parts when

service is required. Failure to use Genuine Hatco

Replacement Parts will void all warranties and may

subject operators of the equipment to hazardous

electrical voltage, resulting in electrical shock or burn.

Genuine Hatco Replacement Parts are specified to

operate safely in the environments in which they are

used. Some aftermarket or generic replacement parts

do not have the characteristics that will allow them to

operate safely in Hatco equipment.

FIRE HAZARD: Locate unit a minimum of 1″ (25 mm) from

combustible walls and materials. If safe distances are not

maintained, discoloration or combustion could occur.

This unit is not intended for use by children or persons

with reduced physical, sensory, or mental capabilities.

Ensure proper supervision of children and keep them away

from the unit.

Make sure all operators have been instructed on the safe

and proper use of the unit.

Make sure food product has been heated to the proper food-

safe temperature before placing on the unit. Failure to heat

food product properly may result in serious health risks. This

unit is for holding preheated food product only.

WARNING

This unit has no “user-serviceable” parts. If service is

required on this unit, contact an Authorized Hatco Service

Agent or contact the Hatco Service Department at

800-558-0607 or 414-671-6350; fax 800-690-2966; or

International fax 414-671-3976.

BURN HAZARD: Some exterior surfaces on the unit will get

hot. Use caution when touching these areas.

Locate unit at proper counter height in an area that is

convenient for use. Location should be level to prevent unit

or its contents from falling accidentally and strong enough

to support the weight of the unit and contents.

Do not operate built-in models without the trim mounting

ring and the control box mounted properly as described in

the installation instructions.

The National Sanitation Foundation (NSF) requires that

units over 36″ (914 mm) in width or weighing more than

″″80 lbs. (36 kg) either be sealed to or raised above the

installation surface. If unit cannot be sealed at the point of

use, 4″ (102 mm) legs are included to allow for proper

cleaning access below unit.

Make sure to clean and sanitize stone surface properly

after deep cleaning the surface using abrasives and before

placing food product on unit.

Damage to any countertop material caused by heat

generated from Hatco equipment is not covered under the

Hatco warranty. Contact the manufacturer of the

countertop material for application information.

Built-in units must not have a setpoint temperature higher

than 200°F (93°C). Temperatures exceeding 200°F (93°C)

will damage unit and void warranty.

Do not modify wiring or cut thermostat capillary on control

box to increase remote mounting distance. Cutting

thermostat capillary will cause unit to overheat and may

damage unit as well as surrounding countertop.

Do not lay unit on the side with the control panel. Damage

to unit could occur.

Use non-abrasive cleaners and cloths only. Abrasive

cleaners and cloths could scratch finish of unit, marring its

appearance and making it susceptible to soil accumulation.

Do not drag or slide unit when moving or installing.

Carefully lift unit to prevent the rubber feet from tearing off.

If weight on shelf exceeds 50 lbs. (23 kg), a deflection up to

5/32 (4 mm) is possible. If weight on shelf exceeds 100 lbs.″

(45 kg), a deflection of 1/4 (6 mm) is possible. Shelf is not″

guaranteed if weight on shelf exceeds 150 lbs. (68 kg). All

weight must be distributed evenly across entire shelf.

NOTICE

CAUTION

WARNING

Read the following important safety information before using this equipment to avoid serious

injury or death and to avoid damage to equipment or property.

Especificaciones del producto

Marca:	Hatco
Categoría:	plato calentador
Modelo:	Glo-Ray GRSS-2418
Colocación del dispositivo:	Vrijstaand
Tipo de operación:	Knoppen
Color del producto:	Roestvrijstaal
Bisagras de puerta:	Links
Pantalla incorporada:	Ja
Peso.:	260000 g
Ancho:	887 mm
Profundidad:	629 mm
Altura:	2120 mm
Impuesto neto:	- W
Longitud del cable:	2 m
Nivel de ruido:	40 dB
Consumo-anual-de-energía:	453 kWu
Clase de eficiencia energética (antigua):	A+
Capacidad bruta del congelador:	- l
Capacidad neta del congelador:	108 l
Capacidad de congelación:	- kg/24u
Dirección de apertura de puerta intercambiable.:	Nee
Capacidad neta del frigorífico:	263 l
Frigorífico de capacidad bruta:	- l
Sin escarcha (nevera):	Ja
Iluminación interior del frigorífico:	Ja
tipo-de-lámpara:	LED
Número de estantes en el refrigerador.:	4
Número-de-cajones-para-verduras:	2
Posición del congelador:	Onder
Sin escarcha (congelador):	Ja
Tiempo de retención en caso de corte de energía:	- uur
Número de estantes del congelador:	2
Capacidad neta total:	496 l
Alarma de temperatura:	Ja
Botellero:	Ja
Capacidad bruta total:	- l
Altura del compartimento de instalación:	2134 mm
Material del estante:	Gehard glas
Bolsillos en las puertas del refrigerador:	3
Al área del compartimento:	Ja
Fuente-de-alimentación:	Electrisch
Alarma de puerta abierta:	Ja
Actual:	16 A
Profundidad cuando la puerta está abierta.:	1470 mm
Certificación:	CE
Filtro de agua:	Ja
Por ángulo de apertura:	105 °
Capacidad bruta del compartimento de la zona fresca:	125 l
voltaje-de-entrada-de-CA:	220 - 240 V
Frecuencia-de-entrada-de-CA:	50 Hz
Tipo-de-visualización:	LED