Intellihot iN401 Manual de Usario

Intellihot Calderas y calderas iN401

Lee a continuación 📖 el manual en español para Intellihot iN401 (79 páginas) en la categoría Calderas y calderas. Esta guía fue útil para 4 personas y fue valorada con 4.5 estrellas en promedio por 2 usuarios

Descargar PDF
Página 1/79
Operation & Installation Manual
iN401
iN501
WARNING
If the information in these instructions is not followed
exactly, a re or explosion could result causing
property damage, personal injury, or death.
— Do not store or use gasoline r other ammable o
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call our gas uppliery s from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
re department.
— Installation and service must e performed by b
a qualied installer, service agency, or the gas
supplier.
— Ne pas entreposer ni utiliser d’essence ou
ni d’autres vapeurs ou liquides inammables
à proximité de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
•
Ne pas tenter d’allumer d’appareil.
•
Ne touchez à aucun interrupteur; ne pas vous
s t tervir des éléphones se rouvant dans
le bâtiment.
•
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. uivez les instructionS s
du fournisseur.
•
Si vous ne pouvez rejoindre le fournisseur,
appelez le service des incendies.
— L’installation et l’entretien doivent être assurés
par un installateur ou un service d’entretien
qualié ou par le fournisseur de gaz.
AVERTISSEMENT
Assurez-vous de bien suivre les instructions données
dans cette notice pour réduire au minimum le
risque d’incendie ou d’explosion ou pour éviter tout
dommage matériel, toute blessure u la mort. o
Thank you for purchasing this Intellihot unit.
This unit is designed for years of trouble free operation, and I urge you to read and follow the
instructions in this “Operation & Installation Manual.”
Our mission to create a better heating system began back in the winter of 2005 when a tank
water heater broke down and flooded my basement. By combining the principles of a diesel
engine’s robustness, robotics intelligence, and marine environment durability, we set out to
design a unit from the ground up that would outperform and outlast all others.
Quickly, our goal grew from not just making a better water heater, but creating an intelligent
water heating and delivery system. Innovation is our hallmark and simplicity, efficiency, and
durability are at the core of every lntellihot product.
Our products are proudly engineered and built in Galesburg, Illinois. lntellihot has helped
commercial customers throughout the nation save thousands of dollars while eliminating
downtime. Our talented team of dedicated professionals is ready to assist you and help your
business succeed.
I thank you for purchasing our lntellihot products.
Sincerely,
Sri Deivasigamani
CEO, lntellihot Inc.
Table of Contents
1. General Information
1.1 Items Shipped With Water Heater 2. . . . . . . . . .
1.2 Serial Number Locations 2 . . . . . . . . . . . . . . . . .
2. Safety
2.1 Safety Signal Words 3 . . . . . . . . . . . . . . . . . . . .
2.2 Installation Warnings 3 . . . . . . . . . . . . . . . . . . . .
3. TechnicalSpecications
3.1 SpecicationsChart ....................5
3.2 Nomenclature .........................6
3.3 High Elevation Installations . . . . . . . . . . . . . . . 6
3.4 ConnectionSpecications................ 7
3.5 Exhaust Gas Standards 7. . . . . . . . . . . . . . . . . .
3.6 Overall Dimensions 8 . . . . . . . . . . . . . . . . . . . . .
3.7 CongurationOptions ...................9
4. Quick Reference Installation Guide
4.1 Install the Water Heater . . . . . . . . . . . . . . . . . 11
4.2 Pre-Startup Instructions . . . . . . . . . . . . . . . . . 11
5. Preparation Before Installation
5.1 Selecting an Indoor Installation Site 13 . . . . . . .
6. Gas Connection
6.1 Quick Reference Installation Instructions 14 . .
6.2 Fuel Source 14..........................
6.3 Gas Pressure Requirements 14. . . . . . . . . . . . .
6.4 Gas Pressure Regulator 14 . . . . . . . . . . . . . . . .
6.4.1 Venting of Gas Supply Regulators 15. . .
6.5 Length of Gas Supply Line 15 . . . . . . . . . . . . . .
6.6 Gas Piping Material 15. . . . . . . . . . . . . . . . . . . .
6.7 DetermineCorrectGasPipeDiameter..... 15
6.8 GasPipeDripandShut-oValve......... 15
6.9 ConnectingGasLinetoUnit............. 16
6.10 Gas Pipe Sizing Tables . . . . . . . . . . . . . . . . . .17
7. Air Intake Inlet and Exhaust Gas Outlet Pipe
Connections
7.1 Quick Reference Installation Guide 19 . . . . . . .
7.2 TypicalSingleUnitAirIntakeInletand
Exhaust Gas Outlet Pipe Installation 19 . . . . . .
7.3 Two Pipe Vent System (Direct Vent) 20. . . . . .
7.3.1 SingleUnitCongurations.........20
7.3.2 MultipleUnitsCongurations . . . . . . 21
7.3.3 SideWallAirIntakeInletandExhaust
Gas Outlet Pipe Termination 21. . . . . . .
7.3.4 RoofAirIntakeInletandExhaust
Gas Outlet Pipe Termination 22. . . . . . .
7.4 Single Pipe Venting System (Power Vent) 22 .
7.4.1 SingleUnit .....................22
7.4.2 MultipleUnits...................23
7.5 CombustionAirRequirements ...........24
7.6 IntakeAirInletandExhaustGasOutlet
Pipe Diameter and Length. . . . . . . . . . . . . . . 24
7.7 VentingClearanceSpecications.........25
7.8 Exhaust Gas Outlet Pipe Materials 26. . . . . . . .
7.9 AirIntakeInletPipeVentMaterials . . . . . . . 26
7.10 Recommended Exhaust Gas Outlet Pipe
Transitions........................... 27
8. Water Connections
8.1 Quick Reference Installation Instructions 28. . .
8.2 HotWaterConnection..................28
8.3 ColdWaterConnection .................29
8.4 CondensateDrainLine..................29
9. Electrical Power
9.1 Electrical Recommendations 30. . . . . . . . . . . . .
9.2 ConnectionInstructions ................30
10. Adjusting CO2 Level
10.1 General Information 31 . . . . . . . . . . . . . . . . . . .
10.2 AdjustmentProcedure ................. 31
11. Natural Gas to Propane Conversion
11.1 General Information 34. . . . . . . . . . . . . . . . . . . .
11.2 ConversionProcedure .................34
12. Operation
12.1 ControlPanel ........................36
12.2 Turning Water Heater ON and OFF 36 . . . . . . .
12.3 Setting the Time . . . . . . . . . . . . . . . . . . . . . . 37
12.4 AdjustingtheWaterTemperature ........ 37
12.5 Security 38.............................
12.5.1 Setting Passcode Protection 38 . . . . . .
12.5.2ChangingPasscode..............39
12.5.3 Forgot Passcode 40. . . . . . . . . . . . . . . .
12.6 N/A ...............................40
12.7 Temp / Flow 40 . . . . . . . . . . . . . . . . . . . . . . . . .
12.8 Life Screen 41 ..........................
12.9 UnitInformation ......................42
12.10 More Screens . . . . . . . . . . . . . . . . . . . . . . . . 43
12.10.1Cellular .......................43
12.10.2 Error History 43 . . . . . . . . . . . . . . . . . .
12.10.3telliCareService
(Subscribe at Startup) 44 . . . . . . . . . .
13. Connecting Multiple Units
13.1 General Information 47 . . . . . . . . . . . . . . . . . . .
13.2 Installation Procedure 47. . . . . . . . . . . . . . . . . .
13.2.1 telliCareforMultipleUnits ........48
13.3 VentingformultipleUnits...............49
14. Maintenance
14.1 Maintenance-FreeCirculationPump . . . . . . 49
14.2 Heat Engine Locations 49 . . . . . . . . . . . . . . . . .
14.3 CondensateSedimentCupCleaning . . . . . . 50
14.4 Wye Strainer 50 . . . . . . . . . . . . . . . . . . . . . . . .
15. Wiring Diagrams and Troubleshooting
15.1 OperationalFlowChart................. 51
15.2 CompleteWiringDiagram(allmodels) .....52
15.3 Troubleshooting Guide 54 . . . . . . . . . . . . . . . . .
16. Serviceable Parts . . . . . . . . . . . . . . . . . . . . . . . .59
17. Requirements for State of Massachusetts
17.1 Notice Before Installation. . . . . . . . . . . . . . . 67
18. Warranty
18.1 Warranty 68............................
19. Product Warranty
19.1 Warranty 70............................

Especificaciones del producto

Marca: Intellihot
Categoría: Calderas y calderas
Modelo: iN401

¿Necesitas ayuda?

Si necesitas ayuda con Intellihot iN401 haz una pregunta a continuación y otros usuarios te responderán


Calderas y calderas Intellihot Manuales

Intellihot

Intellihot iQ2001 Gen II Manual de Usario

29 Agosto 2024
Intellihot

Intellihot iQ251D Gen II Manual de Usario

28 Agosto 2024
Intellihot

Intellihot iQ1501 Gen II Manual de Usario

28 Agosto 2024
Intellihot

Intellihot i250 Gen II Manual de Usario

28 Agosto 2024
Intellihot

Intellihot iQ251 Gen II Manual de Usario

27 Agosto 2024
Intellihot

Intellihot i200 Gen II Manual de Usario

27 Agosto 2024
Intellihot

Intellihot iN199 Manual de Usario

27 Agosto 2024
Intellihot

Intellihot iQ3001 Gen II Manual de Usario

27 Agosto 2024
Intellihot

Intellihot iN401 Manual de Usario

27 Agosto 2024
Intellihot

Intellihot iQ1001 Gen II Manual de Usario

27 Agosto 2024

Calderas y calderas Manuales

Últimos Calderas y calderas Manuales

Cointra

Cointra Optima COB-10 b Manual de Usario

26 Octubre 2024
Daikin

Daikin EKHWSU200BA3V3 Manual de Usario

23 Octubre 2024
Daikin

Daikin VRVIII-C Manual de Usario

22 Octubre 2024
Daikin

Daikin EHVH08S18CB3VF Manual de Usario

22 Octubre 2024
Daikin

Daikin EHVH04S18CB3VF Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWSU150BA3V3 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWS200BA3Z2 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHBRD016ADV17 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHBRD014ADV17 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWS150BA3V3 Manual de Usario

22 Octubre 2024