Intellihot iQ251 Gen II Manual de Usario

Intellihot Calderas y calderas iQ251 Gen II

Lee a continuación 📖 el manual en español para Intellihot iQ251 Gen II (68 páginas) en la categoría Calderas y calderas. Esta guía fue útil para 10 personas y fue valorada con 4.5 estrellas en promedio por 2 usuarios

Descargar PDF
Página 1/68
Operation & Installation Manual
iQ251, Gen II
WARNING
If the information in these instructions is not followed
exactly, a re or explosion could result causing
property damage, personal injury, or death.
— Do not store or use gasoline or other ammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
re department.
— Installation and service must be performed by
a qualied installer, service agency, or the gas
supplier.
— Ne pas entreposer ni utiliser d’essence ou
ni d’autres vapeurs ou liquides inammables
à proximité de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
•
Ne pas tenter d’allumer d’appareil.
•
Ne touchez à aucun interrupteur; ne pas vous
servir des téléphones se trouvant dans
le bâtiment.
•
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions
du fournisseur.
•
Si vous ne pouvez rejoindre le fournisseur,
appelez le service des incendies.
— L’installation et l’entretien doivent être assurés
par un installateur ou un service d’entretien
qualié ou par le fournisseur de gaz.
AVERTISSEMENT
Assurez-vous de bien suivre les instructions données
dans cette notice pour réduire au minimum le
risque d’incendie ou d’explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
Thank you for purchasing this Intellihot unit.
This unit is designed for years of trouble free operation, and I urge you to read and follow the
instructions in this “Operation & Installation Manual.”
Our mission to create a better heating system began back in the winter of 2005 when a tank
water heater broke down and ooded my basement. By combining the principles of a diesel
engine’s robustness, robotics intelligence, and marine environment durability, we set out to
design a unit from the ground up that would outperform and outlast all others.
Quickly, our goal grew from not just making a better water heater, but creating an intelligent
water heating and delivery system. Innovation is our hallmark and simplicity, e ciency, and
durability are at the core of every lntellihot product.
Our products are proudly engineered and built in Galesburg, Illinois. lntellihot has helped
commercial customers throughout the nation save thousands of dollars while eliminating
downtime. Our talented team of dedicated professionals is ready to assist you and help your
business succeed.
I thank you for purchasing our lntellihot products.
Sincerely,
Sri Deivasigamani
CEO, lntellihot Inc.
3 iQ251
Jan 21 2 20 - Revision 0
Table of Contents
1. General Information
1.1 Items Shipped With Water Heater. . . . . . . . . . 5
1.2 Serial Number Plate Locations . . . . . . . . . . . . 5
2. Safety
2.1 Safety Signal Words. . . . . . . . . . . . . . . . . . . . . 6
2.2 Installation Warnings . . . . . . . . . . . . . . . . . . . . 6
3. Technical Speci cations
3.1 Speci cations Chart . . . . . . . . . . . . . . . . . . . . 8
3.2 High Elevation Installations . . . . . . . . . . . . . . . 8
3.3 Clearance Requirements . . . . . . . . . . . . . . . . . 9
3.4 Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
3.5 Exhaust Gas Standards . . . . . . . . . . . . . . . . . . 9
3.6 Dimensional Speci cations . . . . . . . . . . . . . . 10
4. Preparation Before Installation
4.1 Selecting an Indoor Installation Site . . . . . . . . 11
4.2 Selecting an Outdoor Installation Site . . . . . . 12
5. Wall Mounting
5.1 Mounting the Unit to the Wall . . . . . . . . . . . . 13
6. Gas Connection
6.1 Quick Reference Installation Instructions . . . 14
6.2 Fuel Source . . . . . . . . . . . . . . . . . . . . . . . . . . 14
6.3 Gas Pressure Requirements . . . . . . . . . . . . . 14
6.4 Gas Pressure Regulator . . . . . . . . . . . . . . . . . 14
6.4.1 Venting of Gas Supply Regulators . . . 14
6.5 Length of Gas Supply Pipe . . . . . . . . . . . . . . 14
6.6 Gas Piping Material . . . . . . . . . . . . . . . . . . . . 15
6.7 Determine Correct Gas Pipe Diameter . . . . . 15
6.8 Gas Pipe Drip Leg and Shut-o Valve . . . . . . 15
6.9 Gas Pipe Sizing Tables . . . . . . . . . . . . . . . . . . 16
7. Air Intake Inlet and Exhaust Gas Outlet Pipe
Connections
7.1 Quick Reference Installation Guide . . . . . . . . 18
7.2 Typical Single Unit Air Intake Inlet and
Exhaust Gas Outlet Pipe Installation . . . . . . . 18
7.3 Two Pipe Vent System (Direct Vent) . . . . . . 19
7.3.1 Single Unit Con gurations . . . . . . . . . 19
7.3.2 Multiple Units Con gurations . . . . . . . 20
7.3.3 Side Wall Air Intake Inlet and Exhaust
Gas Outlet Pipe Termination. . . . . . . . 20
7.3.4 Roof Air Intake Inlet and Exhaust Gas
Outlet Pipe Termination . . . . . . . . . . . 21
7.4 Single Pipe Venting System (Power Vent) . . 21
7.4.1 Single Unit . . . . . . . . . . . . . . . . . . . . . . 21
7.4.2 Multiple Units . . . . . . . . . . . . . . . . . . . 22
7.4.3 Concentric Venting Termination
(Single Unit) . . . . . . . . . . . . . . . . . . . . 22
7.4.4 Concentric Venting Termination
(Multiple Units) . . . . . . . . . . . . . . . . . . 23
7.5 Intake Air Requirements . . . . . . . . . . . . . . . . 24
7.6 Intake Air Inlet and Exhaust Gas Outlet Pipe
Diameter and Length . . . . . . . . . . . . . . . . . . . 24
7.7 Venting Clearance Speci cations . . . . . . . . . 25
7.8 Exhaust Gas Outlet Pipe Materials . . . . . . . . 26
7.9 Air Intake Inlet Pipe Vent Materials . . . . . . . . 26
7.10 Recommended Exhaust Gas Outlet Pipe
Transitions . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
8. Water Connections
8.1 Quick Reference Installation Instructions . . . 28
8.2 Hot Water Connection . . . . . . . . . . . . . . . . . . 28
8.3 Cold Water Connection . . . . . . . . . . . . . . . . . 29
8.4 Condensate Drain Line. . . . . . . . . . . . . . . . . . 29
8.5 External Recirculation Options . . . . . . . . . . . 31
9. Electrical
9.1 Electrical Code Requirements . . . . . . . . . . . . 33
9.2 Electrical Connection and Polarity. . . . . . . . . 33
10. Adjusting CO2 Level
10.1 General Information . . . . . . . . . . . . . . . . . . . . 34
10.2 Adjustment Procedure . . . . . . . . . . . . . . . . . . 34
11. Natural Gas to Propane Conversion
11.1 General Information . . . . . . . . . . . . . . . . . . . . 37
11.2 Conversion Procedure . . . . . . . . . . . . . . . . . 37
12. Operation
12.1 Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . 39
12.2 Turning Water Heater ON and OFF . . . . . . . . 39
12.3 Setting the Time . . . . . . . . . . . . . . . . . . . . . . 40
12.4 Adjusting the Water Temperature . . . . . . . . . 40
12.5 Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
12.5.1 Setting Passcode Protection . . . . . . . 41
12.5.2 Forgot Passcode . . . . . . . . . . . . . . . . . 41
12.6 iNTouch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
12.7 Life Screen. . . . . . . . . . . . . . . . . . . . . . . . . . . 42
12.8 Unit Information. . . . . . . . . . . . . . . . . . . . . . . 42
12.9 More Screens. . . . . . . . . . . . . . . . . . . . . . . . . 43
12.9.1 Wi-Fi . . . . . . . . . . . . . . . . . . . . . . . . . . 43
12.9.2 Error History . . . . . . . . . . . . . . . . . . . . 43
12.9.3 telliCare Service (Subscribe at Startup) 44
13. Connecting Multiple Units
13.1 General Information . . . . . . . . . . . . . . . . . . . . 46
13.2 Installation Procedure . . . . . . . . . . . . . . . . . . 46
13.2.1 telliCare for Multiple Units . . . . . . . . . 48
14. Maintenance
14.1 Cleaning the Inlet Water Strainer . . . . . . . . . 49
14.2 Draining the Water Heater . . . . . . . . . . . . . . . 49
14.3 Filling the Water Heater. . . . . . . . . . . . . . . . . 50
15. Wiring Diagrams and Troubleshooting
15.1 Operational Flow Chart . . . . . . . . . . . . . . . . . 51
15.2 Complete Wiring Diagram (all models) . . . . . 52
15.3 Troubleshooting Guide. . . . . . . . . . . . . . . . . . 53
16. Serviceable Parts
16.1 Electrical Components . . . . . . . . . . . . . . . . . 56
16.2 Water Lines and Fittings . . . . . . . . . . . . . . . . 57
16.3 Blower, Gas Valve . . . . . . . . 58and . . . .. . . .. . . .
16.4 Exhaust and Air Intake . . . . . . . . . . . . . . . . . . 59
16.5 Miscellaneous . . . .. . . . . . . . . . . . . . . . . . . . . . 60
17. Requirements for State of Massachusetts
17.1 Notice Before Installation . . . . . . . . . . . . . . . 61
18. Warranty
18.1 Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
19. Product Warranty
19.1 Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65

Especificaciones del producto

Marca: Intellihot
Categoría: Calderas y calderas
Modelo: iQ251 Gen II

¿Necesitas ayuda?

Si necesitas ayuda con Intellihot iQ251 Gen II haz una pregunta a continuación y otros usuarios te responderán


Calderas y calderas Intellihot Manuales

Intellihot

Intellihot iQ251D Gen II Manual de Usario

28 Agosto 2024
Intellihot

Intellihot iQ251 Gen II Manual de Usario

27 Agosto 2024
Intellihot

Intellihot i200 Gen II Manual de Usario

27 Agosto 2024

Calderas y calderas Manuales

Últimos Calderas y calderas Manuales

Cointra

Cointra Optima COB-10 b Manual de Usario

26 Octubre 2024
Daikin

Daikin EKHWSU200BA3V3 Manual de Usario

23 Octubre 2024
Daikin

Daikin VRVIII-C Manual de Usario

22 Octubre 2024
Daikin

Daikin EHVH08S18CB3VF Manual de Usario

22 Octubre 2024
Daikin

Daikin EHVH04S18CB3VF Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWSU150BA3V3 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWS200BA3Z2 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHBRD016ADV17 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHBRD014ADV17 Manual de Usario

22 Octubre 2024
Daikin

Daikin EKHWS150BA3V3 Manual de Usario

22 Octubre 2024